Skip to main content
  • Research article
  • Open access
  • Published:

Exposure of bakery and pastry apprentices to airborne flour dust using PM2.5 and PM10personal samplers

Abstract

Background

This study describes exposure levels of bakery and pastry apprentices to flour dust, a known risk factor of occupational asthma.

Methods

Questionnaires on work activity were completed by 286 students. Among them, 34 performed a series of two personal exposure measurements using a PM2.5 and PM10 personal sampler during a complete work shift, one during a cold ("winter") period, and the other during a hot ("summer") period.

Results

Bakery apprentices experience greater average PM2.5 and PM10 exposures than pastry apprentices (p < 0.006). Exposure values for both particulate fractions are greater in winter (average PM10 values among bakers = 1.10 mg.m-3 [standard deviation: 0.83]) than in summer (0.63 mg.m-3 [0.36]). While complying with current European occupational limit values, these exposures exceed the ACGIH recommendations set to prevent sensitization to flour dust (0.5 mg.m-3). Over half the facilities had no ventilation system.

Conclusion

Young bakery apprentices incur substantial exposure to known airways allergens, a situation that might elicit early induction of airways inflammation.

Peer Review reports

Background

Bakers and pastry cooks are exposed to flour dust and associated aeroallergen during the process of flour manipulation [13]. This may elicit airways sensitization and trigger the chain of events eventually leading to occupational asthma. A variety of respiratory effects have been described among bakers, including impairment of pulmonary function and chronic bronchitis [1, 411]. Bakery is described as an occupation at risk of asthma [6, 1214] and ranks first, in France, based on data from the national observatory of occupational asthma [15].

Exposure to flour dust of bakers, pastry-makers and mills workers is well documented. For instance, in 1989, Musk et al measured total dust workplace levels among doughmakers and oven staff and described average values of 2.7 mg.m-3 and 1.7 mg.m-3 respectively, extreme figures reaching up to 14.1 and 37.6 mg.m-3 [1]. Jauhiainen measured total dust workplace concentrations among subjects making dough (average concentrations of 4.6 mg/m3, ranging [0.9–14.7]) or making bread (2.3 [1.5–3.5] mg.m-3) [2]. In a recent study, Bulat [16] measured average concentrations of 2.1 [0,3–13,3] mg.m-3 during a complete shift among bakers [16]. Inhalable dust concentrations among workers whose tasks were described as "weighing and mixing", and "making dough" were in the same order of magnitude (4.7 mg.m-3 (average concentrations) and 3.3 mg.m-3) [17].

By contrast, there is a lack of data regarding exposure among bakery or pastry apprentices, although respiratory conditions have been described in this young population [1824]. In the framework of a prospective study aiming at assessing how non asthmatic bakery and pastry apprentices may develop airway inflammation early in the course of their training, an exposure study was undertaken to assess personal exposure to flour dust and to describe the tasks that involve contact with flour in the bread making and pastry confectioning processes.

Methods

With the collaboration of a large apprenticeship school in Nancy, Lorraine region, in NorthEast of France, we conducted a cross-sectional study in different classes of bakery and pastry training programmes during the 2003–2004 and 2004–2005 academic years. The study involved two stages. First, all apprentices following the first or second year of their training programme completed in their classroom (with 20 to 30 apprentices per classroom) a questionnaire describing their work environment and activities. In the second stage, volunteers were asked to participate to personal exposure measurements while at work. Agreement of the bakers and pastry confectioners who trained the volunteering apprentices was also requested. Typically, an apprentice works 3 weeks in the bakery or pastry shop and attends school for practical and academic classes during one week. But for special reasons (such as being fired or because of resignation) an apprentice stays in the same bakery or pastry shop until he/she graduates. The field exposure measurement study was conducted during a regular workday, most of the time between Monday and Friday, depending when bakery or pastry shop owners were available.

Completion of questionnaires

The questionnaire was designed after a literature review, observations in several bakeries and following visits during the practical training classes in the apprenticeship school. It was validated by the school instructors and by heads of the local and regional bakery and pastry federations. A pilot study was undertaken during academic year 2002–2003 to check suitability of the questions for the study population. Information of interest encompassed personal characteristics, duration of a work shift, spatial organization of the bakeries or pastry shops, and ventilation characteristics and equipments (automatic or manual organization). The questionnaire also requested students to describe in detail their activities during a "standard" workday. Questionnaire data were input with Epidata software. Statistical analysis was carried out using the SAS statistical package and Statgraphic.

Field exposure measurements and determination of flour dust concentrations

Volunteers for the exposure study were mostly recruited among second graders because younger apprentices were expected to have little technical activities during the first year of training. Further, their enrolment in the school spans over several months and they may change of practice location during the first months of their training programme. After they had declared their willingness to participate to this second stage of the study, during completing of the first phase questionnaire, names and phone numbers of bakery and pastry shop owners or managers were noted, in order for the study coordinator to request authorization to undertake the measurement study in the bakery or pastry shop. Study subjects were given a letter explaining the aim of study and providing general information on asthma and occupational hygiene. Apprentices were asked to participate during two series of personal exposure measurement runs, one during the "cold season", from February to April, and the second during the "hot season", from April to August, in order to asses seasonal variations.

To measure flour dust personal exposures, both PM2.5 and PM10 fractions were collected using the Harvard Chempass sampler [25] connected to a portable BGI pump (model 400) providing an air flow of 1.8 l/min in each sampling head. Measurements were done during a complete 5 to 11 hours work shift, volunteers carrying the sampler installed in a rucksack; the sampling heads were near the breathing zone. Field control filters were also placed in some rucksacks and processed along with those that collected flour dust. After shift, all filters were brought back within one hour to the laboratory and stored in a refrigerator (+/- 4°C) with a dessicator. Particles of flour dust were collected on Teflon filters (Gelman®, diameter 37 mm, porosity 2 μm) that were weighted using a microbalance (Mettler AT 261) with a sensitivity of +/- 0.01 mg. The balance was first calibrated and zeroed before each series of weight. Electrostatic charges on filters were eliminated using a deionization system. Filters were weighed prior to field sampling and after being loaded with flour dust. Controls were also included in the filters batches to be weighed; these batches were composed of 6 flour dust, 4 field control and 10 laboratory control filters. The day prior weighing, filters were retrieved from the refrigerator and kept in a room controlled for temperature (20 +/- 2°C) and humidity (33 +/- 4 % relative humidity). Seasonal variations of exposures were assessed for PM2.5 and PM10 over all bakers and pastry makers, with paired and signed rank tests. Median exposure values between apprentices' groups were compared over the two study seasons with Wilcoxon Mann-Whitney tests, because conditions for parametric tests were not met. However, for the sake of comparability with the literature data, where average values are usually shown, we also exhibit means and standard deviations in the text and table.

Results

All apprentices completed the questionnaires (N = 286). Among them, not all participated to the personal exposure study. Among the 198 apprentices engaged in the second year of their training programme, 58 accepted to contribute to exposure measurements, but 24 employers declined participation; so 34 measurements were done during the cold season and 21 in summer, because of final school exams and tight schedule constraints (Table 1).

Table 1 Description of the study population

Work environment

Table 2 shows the distribution of time spent at work according to the training level and indicates, as expected, longer shifts declared by second graders, especially among bakery apprentices. While all pastry apprentices worked in craft facilities (pastry or combined pastry-bakery), this was the case for 84% of bakery apprentices, 16% being in large bakery-pastry plants). The magnitude of flour handling is greater in craft production conditions.

Table 2 Duration of daily shift declared by apprentices, according to training level

More than 1 out of 3 bakery apprentices (4/5 among pastry apprentices) declared absence of ventilation, be it natural or mechanical, or of air conditioning. For 16% of apprentices, the room where he/she spent most of the time did not have a door opening outside, and 24 % had no window.

Tasks associated with manipulation of flour dust and cleaning activities involving exposure to dust according to the literature are described in Table 3 and 4 which exhibit the frequency distribution of times these tasks are accomplished during a typical day, as reported by the questionnaires. Data are split according to training level; also are exhibited (last column) the answers given by the subgroup of apprentices who volunteered to participate to the exposure measurements. The tasks varied markedly between the two groups (bakers or pastry) according to training year. Second graders, among pastry apprentices, are more engaged than younger students in tasks involving exposure to flour dust (mixing, dividing and shaping dough into pieces, moulding dough pieces; all p values ≤ 0.02). By contrast, tasks are more evenly distributed among the first training year for bakers, only flour weighing for pastry production being more frequent among younger bakery apprentices (75 respondents, p = 0.03).

Table 3 Daily frequencies of activities associated with manipulation of flour dust for bread and pastry production
Table 4 Daily frequency of cleaning activities associated with manipulation or presence of flour dust

Personal exposure measurements

Table 5 presents personal exposure levels to flour dust for bakery and pastry apprentices, according to the particles fraction, respectively during the hot and cold seasons. Average (and standard deviate) personal exposures to PM2.5 for bakery apprentices are respectively 0.50 [0.37] mg.m-3 during the hot season and 0.71 [0.37] mg.m-3 during the cold season (corresponding values for pastry apprentices are 0.29 [0.06] mg.m-3 and 0.35 [0.17] mg.m-3). Exposure values are greater during the cold sampling period over the two apprentices categories (p = 0.009; 21 measurements with both seasonal values). PM10 personal exposures for bakers are 0.63 [0.36] mg.m-3 in summer and 1.10 [0.83] mg.m-3 in winter. Corresponding exposures are respectively 0.47 [0.13] mg.m-3 and 0.44 [0.16] mg.m-3 among pastry apprentices. Again, winter figures are greater over the two apprentices categories (p = 0.003, based on 17 measurements).

Table 5 Personal exposures levels to flour dust of apprentices in bakeries and pastry shops

Average exposures of bakery and pastry apprentices over the two seasons are respectively 0.61 [0.38] mg.m-3 and 0.32 [0.15] mg.m-3 for PM2.5 (corresponding PM10 values are 0.87 [0.70] mg.m-3 and 0.46 [0.15] mg.m-3).Median values for PM2.5 (p = 0.006) and PM10 (p = 0.001) were significantly greater among bakers.

To assess whether seasonal variations of humidity could have altered filters weight comparisons, differences of pre and post sampling weights were compared between the two study periods and showed similar patterns (n = 80 ; p = 0.96).

Discussion

According to published data, average exposure levels (inhalable or total dust) for weighing, mixing, dividing, moulding, dough and bread making, and cleaning span from 2.3 to 11.0 mg.m-3. For oven workers, levels range between 0.6 to 3.2 mg.m-3. The lowest levels are found for bread wrapping activities (also including slicing activities), with values lower than 1 mg.m-3 [13, 10, 16, 17, 2630].

Enrolment of apprentices into this study was hampered by several factors. Health is not a serious concern in this population mainly composed of teenagers, mostly from families of modest origin, not keen to contribute to health studies, according to our experience. Also, some apprentices said they would not volunteer because they feared refusal or rebuttal from their employer. Indeed, constraints posed to apprentice volunteers and to the bakery and pastry-shop managers were not trivial, in particular during Christmas or Easter holidays, when activity is great. For these reasons, we were unable to sample study locations across strata (e.g. small or large facilities; solo crafts or within commercial malls; or according to anticipated levels of concentrations of flour dust), as we had expected. Our experience, however, is that the types of facilities and indoor environments of small craft bakeries or pastries do not vary greatly in the Lorraine region. Our sample was composed of too few large facilities to draw conclusions for this category of work environment. Hence, while this is not a random sample, exposure data can be viewed as indicative of typical values currently found in small facilities. In order to assess the comparability of volunteers that underwent exposure measurements and subjects who only contributed to the questionnaire study, we compared 17 descriptive variables (e.g. type of shops, ventilation characteristics, number of working hours over the week, and different production activities such as daily number of mixing, dividing and shaping dough into pieces), both using the whole study sample and selecting only the second graders; none of these variables showed statistical differences (all p value > 0.09). One should note, however, that our results might underestimate true exposure distributions since, in our experience, employers of apprentices working in poor conditions were less likely to enrol in the study. Questionnaires were designed to obtain descriptive information on work activities and environmental conditions of apprentices in bakeries and pastries. In order to minimize recall bias, tasks we explored for a typical day to be chosen within the ongoing week; it was frequently the previous day.

Why work tasks were found to differ according to year of training among pastry apprentices but not among bakery apprentices may relate to their relative complexity. Learning how to prepare bread loafs does not take a long time while pastry making requires more technical know-how. Hence, bakery apprentices soon start to work with the baker during the first year. Bakery apprentices may also be trained to do some pastry, and conversely. Interestingly, training level differences among the two groups occur for these alternate activities, confirming that introduction to pastry know-how occurs later among bakery apprentices while, because they are more experienced, second year pastry apprentices may often help their employer to prepare bread.

Unfortunately, because it is such a routine gesture, sifting (or sieving) could not be specifically quantified with the study questionnaires; now, it incurs suspension of flour dust and therefore is an important exposing activity [11, 17, 28].

Comparison of exposure results across the literature should be done with caution because time and space sampling procedures, measurement techniques and methods of analyses are not readily comparable. One reason is that all published data deal with older subjects, rather than with apprentices. Working conditions of bakers or pastry-makers vary across countries according to bread or cake making processes. Further, our results are expressed in terms of personal shift exposure rather than workplace concentrations, and many published data focus on exposures during specific tasks incurring higher exposures. Finally, we measured PM2.5 and PM10 particles fractions, while literature data usually describe the 'respirable' (in the range of [1 – 4] μm), 'thoracic' ([1 – 10] μm), 'inhalable' particles ([1–100] μm) and total dust [1, 2, 31]. We acknowledge this may render comparisons with literature data less easy. In addition to practical reasons (availability of samplers), we wanted to compare exposure levels for two particle fractions. Also, one should keep in mind that differences between published exposure data, and how respirable and thoracic particles relate respectively to our PM2.5 and PM10 results depend on the granulometric distribution of flour, which is not documented in the literature and is most probably site and time specific, according to flour production processes. Personal exposures to total dust were evaluated in three large British bakeries, with geometric means ranging from 0.4 to 6.4 mg.m-3 [3]. The same authors assessed peak total dust exposures during task measurements and described geometric means between 1.4 and 42.9 mg.m-3 [8]. One French personal flour dust exposure study in an industrial bakery showed average levels about 4.9 mg.m-3 [32]. Two exposure studies encompassed personal inhalable dust measurements among bakers doing three tasks: dough mixing, dough forming and oven control [26, 27]. Mean dust exposure levels of dough mixing bakers were 5.5 and 7.5 mg.m-3 respectively, 2.7 – 2.5 mg/m3 for dough forming, and 1.2 – 3.2 mg.m-3 among bakers working in the oven control area [26, 27]. Burstyn et al. measured personal inhalable exposures to flour dust and found exposures spanning from 0.1 to 110 mg.m-3 according to tasks [28]. A study separated bread bakeries (n = 19) and cake bakeries (n = 3) using personal samplers of total inhalable dust. Higher exposures were found for sieving activities (8.2 mg.m-3), followed by weighing (2.7 mg.m-3); the same tasks performed with no exhaust ventilation in the room showed greater values [11]. In another study, the geometric means of personal inhalable flour dust during sieving mixing or weighing were 4.7 mg.m-3, 3.3 mg.m-3 for dough making activities and greater for cleaning activities (3.8 mg.m-3) [17].

Respiratory symptoms and sensitisation in relation to exposure of bakers to flour dust have been described in several studies [1, 7, 13, 3335]. In large or industrial bakeries, prevalence of nasal symptoms (19%), chest symptoms (13%) and chest tightness (7%) were associated with workplace total dust concentrations ranging about [0.01–11.0] mg.m-3 [1]. In the Netherlands, a study in confectioneries, crisp-bake (rusk) factory, rye-bread factory and small bakeries, showed prevalences of rhinitis and chest tightness among workers respectively of 15% and 5%, with geometric means of full-shift airborne inhalable dust concentrations spanning from 0.6 to 3.0 mg.m-3 (with range [0.1–37.7] mg.m-3) [9, 10, 13].

With cautious comparison, as stated above, one may see that our exposure figures are in general smaller than those found in the literature for inhalable or total dust. Further, exposures of apprentices are beyond the French TWA-TLV for non specific respirable and inhalable dust (5 and 10 mg.m-3 respectively, with no specific limit value for flour dust) [31] and beyond the British flour dust MEL which was set at 10 mg.m-3 [17, 36]. Finland, Iceland and Norway have established exposure limits for total organic dust at 5 mg.m-3 while in Denmark and Germany, flour dust occupational exposure limits are respectively 3 and 4 mg.m-3 [37]. Now, the ACGIH recommends a lower 0.5 mg.m-3 TLV for inhalable flour dust, with a view to protect against sensitization and other respiratory symptoms [37, 38]. Our study PM10 average exposure values are close to this ACGIH TLV among pastry apprentices, and greater among bakery apprentices, a finding which is of concern despite compliance with existing standards in Europe. Exceedance also holds true among bakers for PM2.5.

We are not aware of exposure studies among apprentices. However, respiratory conditions and skin tests reactivity have been described among bakery trainees. An increased trend of positive skin tests was found in two surveys separated by five years in the 60ies and 70ies [18, 19]. A recent study described incidence rates of respiratory symptoms (shortness of breath, wheezing, exercise induced symptoms) among pastry-makers apprentices of 5.4 per 100 person-years, 8.7 per 100 p-y and 7.7 per 100 p-y respectively [23]. Cough, dyspnoea, rhinitis, conjunctivitis and positive skin prick tests (SPT) to flour allergens were reported among bakery apprentices [20]. The authors concluded that SPT with common and occupational allergens should be performed among bakery apprentices before their training to identify subjects at highest risk of sensitisation [22, 24]. In another study the same authors demonstrated hypersensitivity to occupational allergens among 18.1% of bakery apprentices, by skin prick tests, with occurrence of IgE antigen during the follow-up period. Incidence of occupational asthma and rhinitis was shown to increase with duration of exposure [21].

Conclusion

Manipulation of flour dust is a known risk factor for respiratory conditions, in particular for asthma. While lower than the French TWA-TLV for respirable or inhalable non specific dust, personal exposure values of young bakery apprentices are greater than the ACGIH recommendation. General or process ventilation devices were not frequent in the study facilities, and this is likely to contribute to these exposure values. Further, sifting while preparing bread loafs has been shown to generate inhalation of dust. These findings suggest that further occupational hygiene progresses may result from a combination of efforts entailing modification of the granulometric profile of flour used for sifting, that would lead to more rapid deposition, improvements in facility and process ventilation, and information of bakers, including young apprentices during their training, as to potential hazards in the workplace. Also, flour dust exposures could be reduced using up-to-date process technology (i.e. decrease large sieving machinery) and proper cleaning procedures.

Abbreviations

PM2.5 :

Particule matter 2.5 μm

PM10 :

Particule matter 10 μm

References

  1. Musk AW, Venables KM, Crook B, Nunn AJ, Hawkins R, Crook GD, Graneek BJ, Tee RD, Farrer N, Johnson DA, Gordon DJ, Darbyshire JH, Newman Taylor AJ: Respiratory symptoms, lung function, and sensitisation to flour in a British bakery. Br J Ind Med. 1989, 46: 636-642.

    CAS  PubMed  PubMed Central  Google Scholar 

  2. Jauhiainen A, Louhelainen K, Linnainmaa M: Exposure to Dust and alpha-Amylase in Bakeries. Appl Occup Environ Hyg. 1993, 8: 721-725.

    Article  CAS  Google Scholar 

  3. Nieuwenhuijsen MJ, Sandifort CP, Lowson D, Tee RD, Venables KM, Mac Donald JC, Newman Taylor AJ: Dust and flour aeroallergen exposure in flours mills and bakeries. Occup Environ Med. 1994, 51: 584-588.

    Article  CAS  PubMed  PubMed Central  Google Scholar 

  4. Hartmann AL, Wüthrich B, Deflorin-Stolz R, Helfenstein U, Hewitt R, Guérin B: [Atopie-Screening: Prick-Multitest, Gesamt-IgE oder RAST?]. Schweiz med Wschr. 1985, 115: 466-475.

    CAS  PubMed  Google Scholar 

  5. Hartmann AL: Berufsallergien bei Bäckern: Epidemiologie; Diagnose, Therapie und Prophylaxe; Versicherungsrecht. 1986, München-Deisenhofen, Germany: Dustri-Verlag, Dr. karl Feistle

    Google Scholar 

  6. Lagier F, Cartier A, Malo JL: Statistiques médico-légales sur l'asthme professionnel au Québec de 1986 à 1988. Rev Mal Res. 1990, 7: 337-341.

    CAS  Google Scholar 

  7. Cullinan P, Lowson D, Nieuwenhuijsen MJ, Gordon S, Tee RD, Venables KM, McDonald JC, Newman Taylor AJ: Work-related symptoms, sensitisation, and estimated exposure in workers not previously exposed to flour. Occup Environ Med. 1994, 51: 579-583.

    Article  CAS  PubMed  PubMed Central  Google Scholar 

  8. Nieuwenhuijsen MJ, Sandifort CP, Lowson D, Tee RD, Venables KM, Mac Donald JC, Newman Taylor AJ: Peak exposure concentrations of Dust and flour aeroallergen exposure in flours mills and bakeries. Ann Occup Hyg. 1995, 39 (2): 193-201.

    Article  CAS  PubMed  Google Scholar 

  9. Houba R, Heederik DJJ, Doekes G, Van Run PE: Exposure-Sensitization Relationship for α-amylase Allergens in the Baking Industry. Am J Respir Crit Care Med. 1996, 154: 130-136.

    Article  CAS  PubMed  Google Scholar 

  10. Houba R, Van Run P, Heederik D, Doekes G: Wheat antigen exposure assessment for epidemiological studies in bakeries using personal dust sampling and inhibition ELISA. Clin Exp Allergy. 1996, 26: 154-163. 10.1111/j.1365-2222.1996.tb00074.x.

    Article  CAS  PubMed  Google Scholar 

  11. Smith TA, Wastell Smith P: Respiratory symptoms and sensitizition in bread and cake bakers. Occup Med. 1998, 48 (5): 321-328. 10.1093/occmed/48.5.321.

    Article  CAS  Google Scholar 

  12. Nordman H: Occupational asthma--time for prevention. Scand J Work Environ Health. 1994, 20 (Spec No): 108-115.

    CAS  PubMed  Google Scholar 

  13. Houba R, Doekes G, Heederik D: Occupational Respiratory Allergy in Bakery Workers: A Review of the Literature. Am J Ind Med. 1998, 34: 529-546. 10.1002/(SICI)1097-0274(199812)34:6<529::AID-AJIM1>3.0.CO;2-I.

    Article  CAS  PubMed  Google Scholar 

  14. Brisman J: Baker's Asthma. Occup Environ Med. 2002, 59: 498-502. 10.1136/oem.59.7.498.

    Article  PubMed  PubMed Central  Google Scholar 

  15. Ameille J, Pauli G, Calastreng-Crinquand A, Vervloët D, Iwatsubo Y, Popin E, Bayeux-Dunglas MC, Kopferschmitt-Kubler MC: Reported incidence of occupational asthma in France, 1996–99: the ONAP programme. Occup Environ Med. 2003, 60: 136-141. 10.1136/oem.60.2.136.

    Article  CAS  PubMed  PubMed Central  Google Scholar 

  16. Bulat P, Myny K, Braeckman L, Van Sprundel M, Kusters E, Doekes G, Possel K, Droste J, Vanhoorne M: Exposure to inhalable dust, wheat flour and alpha-amylase allergens in industrial and traditional bakeries. Ann Occup Hyg. 2004, 48 (1): 57-63. 10.1093/annhyg/meg075.

    Article  CAS  PubMed  Google Scholar 

  17. Elms J, Robinson E, Rahman S, Garrod A: Exposure to Flour Dust in UK Bakeries: Current Use of Control Measures. Ann Occup Hyg. 2005, 49 (1): 85-91.

    CAS  PubMed  Google Scholar 

  18. Herxheimer H: Skin sensitivity to flour in bakers' apprentices. Lancet. 1967, 1: 83-84. 10.1016/S0140-6736(67)92479-8.

    Article  CAS  PubMed  Google Scholar 

  19. Herxheimer H: The skin sensitivity to flour of baker's apprentices. A final report of a long term investigation. Acta Allergol. 1973, 28 (1): 42-49.

    Article  CAS  PubMed  Google Scholar 

  20. Walusiak J, Palczynski C, Wyszynska-Puzanska C, Mierzwa L, Pawlukiewicz M, Ruta U, Krakowiak A, Gorski P: Problems in diagnosing occupational allergy to flour: results of allergologic screening in apprentice bakers. Int J Occup Med Environ Health. 2000, 13 (1): 15-22.

    CAS  PubMed  Google Scholar 

  21. Walusiak J, Palczynski C, Hanke W, Gorski P, Wyszynska-Puzynska C, Mierzwa L, Pawlukiewicz M, Wittczak T, Krakowiak A, Ruta U, Wagrowska-Koski E: [The risk factors of occupational hypersensitivity in apprentice bakers]. Med Pr. 2002, 53 (3): 209-218.

    PubMed  Google Scholar 

  22. Walusiak J, Palczynski C, Hanke W, Wittczak T, Krakowiak A, Gorski P: The risk factors of occupational hypersensitivity in apprentice bakers – the predictive value of atopy markers. Int Arch Occup Environ Health. 2002, S117-S121. 10.1007/s00420-002-0358-9. Suppl 75

  23. Gautrin D, Ghezzo H, Malo JL: Rhinoconjunctivitis, bronchial responsiveness, and atopy as determinants for incident non-work-related asthma symptoms in apprentices exposed to high-molecular-weight allergens. Allergy. 2003, 58 (7): 608-615. 10.1034/j.1398-9995.2003.00197.x.

    Article  CAS  PubMed  Google Scholar 

  24. Walusiak J, Hanke W, Gorski P, Palczynski C: Respiratory allergy in apprentice bakers: do occupational allergies follow the allergic march?. Allergy. 2004, 59 (4): 442-450. 10.1111/j.1398-9995.2003.00418.x.

    Article  CAS  PubMed  Google Scholar 

  25. Demokritou P, Kavouras IG, Ferguson ST, Koutrakis P: Developpement and laboratory performance evaluation of a personal multipollutant sampler for simultaneous measurements of particulate and gaseaous pollutants. Aerosol Sci Technol. 2001, 35: 741-752. 10.1080/02786820152546789.

    Article  CAS  Google Scholar 

  26. Burdorf A, Lillienberg L, Brisman J: Characterization of exposure to inhalable flour dust in Swedish bakeries. Ann Occup Hyg. 1994, 38 (1): 67-78. 10.1093/annhyg/38.1.67.

    Article  CAS  PubMed  Google Scholar 

  27. Lillienberg L, Brisman J: Flour dust in bakeries: A comparison between methods. Ann Occup Hyg. 1994, 38 (Suppl 1): 571-575.

    Article  Google Scholar 

  28. Burstyn I, Teschke K, Kennnedy SM: Exposure levels and determinants of inhalable dust exposure in bakeries. Ann Occup Hyg. 1997, 41 (6): 609-624.

    Article  CAS  PubMed  Google Scholar 

  29. Talini D, Benvenuti A, Carrara M, Vaghetti E, Bianchi Martini L, Paggiaro PL: Diagnosis of flour-induced occupational asthma in a cross-sectional study. Respiratory Medicine. 2002, 96: 236-243. 10.1053/rmed.2001.1259.

    Article  CAS  PubMed  Google Scholar 

  30. Elms J, Beckett P, Griffin P, Evans P, Sams C, Roff M, Curran AD: Job categories and their effect on exposure to fungal alpha-amylase and inhalable dust in the U.K. baking industry. AIHA J (Fairfax, VA). 2003, 64 (4): 467-471.

    Article  CAS  Google Scholar 

  31. Institut National de Recherche et de Sécurité INRS: Valeurs limites d'exposition professionnelle aux agents chimiques en France. ND 2098. Note Documentaire. Mise à jour février 2005. 2005, France

    Google Scholar 

  32. Kolopp-Sarda MN, Massin N, Gobert B, Wild P, Moulin JJ, Bene MC, Faure GC: Humoral immune responses of workers occupationally exposed to wheat flour. Am J Ind Med. 1994, 26 (5): 671-679. 10.1002/ajim.4700260509.

    Article  CAS  PubMed  Google Scholar 

  33. Brisman J, Järvholm B, Lillienberg L: Exposure-response relations for self reported asthma and rhinitis in bakers. Occup Environ Med. 2000, 57 (5): 335-340. 10.1136/oem.57.5.335.

    Article  CAS  PubMed  PubMed Central  Google Scholar 

  34. Cullinan P, Cook A, Nieuwenhuijsen MJ, Sandiford C, Tee RD, Venables KM, McDonald JC, Newman Taylor AJ: Allergen and dust exposure as determinants of work-related symptoms and sensitization in a cohort of flour-exposed workers; a case-control analysis. Ann Occup Hyg. 2001, 45 (2): 97-103.

    CAS  PubMed  Google Scholar 

  35. Heederik D, Houba R: An exploratory quantitative risk assessment for high molecular weight sensitizers: wheat flour. Ann Occup Hyg. 2001, 45 (3): 175-185.

    Article  CAS  PubMed  Google Scholar 

  36. Health and Safety Executive. Occupational exposure limits. 2002, Caerphilly

  37. Karpinski EA: Exposure to Inhalable Flour Dust in Canadian Flour Mills. Appl Occup Environ Hyg. 2003, 18: 1022-1030.

    Article  PubMed  Google Scholar 

  38. American Conference of Governmental Industrial Hygienists. Guide to occupational exposure values. 2002, Cincinnati

Pre-publication history

Download references

Acknowledgements

The authors express their gratitude to the apprentice volunteers who participated in this study, along with their bakery and pastry managers. They thank the Nancy-Laxou apprenticeship school teachers and the heads the local and regional bakery and pastry federations (Fédération Régionale de la Pâtisserie de la Lorraine, Chambre Syndicale des Pâtrons Pâtissiers Confiseur Glacier de Meurthe-et-Moselle, Syndicat de la Pâtisserie de la Moselle, Syndicat de la Pâtisserie de la Meuse, Chambre Syndicale des Pâtissiers Confiseurs Glacier des Vosges, Fédération Régionale des Artisans Boulangers Pâtissiers, Chambre Syndicale de la Boulangerie de la Meuse, Fédération des Artisans Boulangers Pâtissiers des Vosges, Fédération Patronale de la Boulangerie et de la Boulangerie Pâtisserie de la Moselle, Fédération des Artisans Boulangers et Pâtissiers de Meurthe-et-Moselle). Lahoucine Benamghar contributed to the data analysis. We are grateful to the LICE (Laboratoire Inter-régional de Chimie de l'Est) who allowed us to use its particle analysis laboratory. Special thanks to Thierry Grosset, Christian Loriette and Michel Dorotte for their advice and assistance.

This study was performed with grants from AFSSE (contract RD-2003-04), the French Ministry of Labour (2002 Health and Occupation call for proposal), the regional Social Security office (CRAM Nord-Est). The Soufflet group also provided financial support. Estelle Mounier-Geyssant (Ph.D.) was recipient of a doctoral grant from INSERM and the Lorraine Region.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Denis Zmirou-Navier.

Additional information

Competing interests

The author(s) declare that they have no competing interests.

Authors' contributions

EMG coordinated the study, designed the questionnaire, conducted field investigations and performed the filters analyses and the statistical analysis. She is the main author of the manuscript. JFB contributed technical help and has given final approval of the version to be published. LM contributed to the statistical analysis. CP was an advisor for the study design and has given final approval of the version to be published. DZN directed the study and supervised writing of the manuscript. All authors read and approved the final manuscript.

Rights and permissions

Open Access This article is published under license to BioMed Central Ltd. This is an Open Access article is distributed under the terms of the Creative Commons Attribution License ( https://creativecommons.org/licenses/by/2.0 ), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Reprints and permissions

About this article

Cite this article

Mounier-Geyssant, E., Barthélemy, JF., Mouchot, L. et al. Exposure of bakery and pastry apprentices to airborne flour dust using PM2.5 and PM10personal samplers. BMC Public Health 7, 311 (2007). https://doi.org/10.1186/1471-2458-7-311

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1186/1471-2458-7-311

Keywords